The summer solstice is approaching, there is more rain, and the excavator is still working orderly on the construction site. So, how to maintain the excavator on rainy days? Let's take a look with the editor!
The general working environment is not very good, such as mines, construction sites, etc. In addition to the tangshi pavement is basically a dirt road, after the heavy rain, the puddles in many places where the pavement was flushed are accumulated, and the road becomes abnormally slippery, even the excavator Become strenuous.
Observe the traffic
Sometimes, if there is an emergency that requires an excavator to go out to assist in flood control, that ’s the way to go. But be sure to pay attention to safety, especially when working in the rain.
When working in rainy days, pay attention to the conditions of the road surface, especially in places with particularly thick soil. After heavy rain, the soil is wet and wet, especially slippery. When working in these places, you must pay attention to the surrounding environment and always observe. You can use the small throttle to work when pushing materials.
When the excavator is used as a tractor in the rainy season, it must ensure the safety of the excavator. Only when you guarantee your own safety can you rescue others, especially when you are driving on the slope, you must see the road surface clearly. It is better to remove the soil first. If possible, it is better to shovel something like sand and gravel on the road. This can greatly reduce the skidding of the vehicle. Rescue under the condition of ensuring safety must not be exhausted.
Avoid the excavator too close to the cliff, the edge of the ditch, if the ground is soft in these places, it is easy to fall or tip the machine due to the weight and vibration of the excavator.
Excavator parking
It is also particularly important to park the excavator during the rainy season. If possible, it is best to park in the garage. Try to avoid parking in an excessively humid environment. Choose indoor storage. The anti-rust operation is important. Charge the battery. After the machine is stored for a long time, the grease on the piston rod should be wiped off, and the parts should be filled with grease.
When the machine is parked, keep the working device dry and clean, and do not put water into it, otherwise rust will make the machine inconvenient to operate.
Clean in time
After the rainy season, be sure to clean the excavator chassis, maintain and lubricate the necessary places to prevent rust, check whether the oil drain screws are loose, even if maintenance is carried out, the machine should be cleared of the water. Avoid the occurrence of rust and affect the spirituality of the machine.
When parking in the open air, pay attention to check whether the fuel tank and hydraulic tank lids are tightly closed to avoid unnecessary trouble caused by rainwater seeping into the tank.
Equipment maintenance
In rainy days, pay attention to check the filter element of the air filter of the excavator to avoid the ingress of rain, which will cause the paper filter element to be damaged and clogged. Replace and maintain it in time.
In addition, pay attention to the wear of the seal ring on the engine oil scale to avoid the rain from seeping into the oil. The oil filling port should also be checked. A plastic bag can be put on if it is parked in the open, so that it is foolproof.
Check the use of the starter thread to see if there is any looseness or rust, and deal with the problem in time to prevent the starter from being affected by moisture. Check the use of the generator, and avoid moisture in the joints of each line, which will affect the power generation effect.
It is best to park the engine part in the garage during the rainy season. Some careless drivers think that the car can be placed in the garage, but they did not pay attention to the engine part just under the eaves. When the rain rushed to the engine, the scene ... I've seen it with my own eyes, so don't be too careless when parking.
The rainy season excavator should pay attention to windproof, anti-collapse, anti-moisture, anti-skid and so on. Keep vigilant when working in the rain, and keep the normal work of the headlights, work lights, ceiling lights, instrument lights, wipers, etc. of the excavator at night to ensure safety.
